Where Passion Meets Excellence

Chip/Flash Tuning

OBD Flash
With this method we download your ecu software through the vehicle diagnostics port and reload it again. We download your original ecu software file and upload the modified file again, this way the manufacturer cannot pick up if software has been modified as it has the original software back on the ECU.

Bench Flash
Certain vehicles cannot be flashed via the diagnostics port, in that case we remove the ECU from the car and bench flash the ECU. We download your original ecu software file and upload the modified file again, this way the manufacturer cannot pick up if software has been modified as it has the original software back on the ECU.

Plug n’ Play
98% of vehicles can be tuned via OBD and Bench Flash. However there are a few cars that cannot be done in this way. Here we use the proven unichip plug and play.

EFI Flashcvs.cdr    unichip

Custom Remaps

This is for a vehicles that have major hardware modifications, example would be Different exhaust or downpipe and performance air filter, or a turbo upgrade or turbo conversion. It is done the same as the above way of flashing but is very time consuming and it can take up to 6 hours of dyno time. We measure every aspect of the engine from Air Fuel Ratio, Egt’s, and co’s. This will give you the best safe performance from you engine.

ECU Repairs
We repair ECUs for all makes and models of cars.

Spitronics Aftermarket ECU System
We offer these systems to upgrade cars with ECU that cannot be repaired, and to upgrade older systems as your Vw mp9 and Bosch mototronic 1.0 to 2.0 range as these ECU are way to slow. As faster desktop computers are released so are Car ECUs released.

Having the technical knowledge of how an OEM Electronic Fuel Management System works I had a look at systems currently available on our Local market. After testing the units the spitronics unit stood out for us.
1. It works as a OEM management system.
2. It uses and automotive processor which is similar to your latest OEM designed ECU.
3. We flash the firmware onto the ECU the same way as the OEM ECU so there is no way that it will lose its map if there is a voltage spike or any other fault.
4. It has tuning tables similar to a OEM ECU.
5. We can upgrade your old distributor Engine management system to the latest wasted spark sequential fueling with the advance unit.
6. In the unlikely event of a ECU malfunction we can repair it in house without having to send it back to the supplier.
7. It has tuning sites for part throttle and tuning sites for full throttle, therefore it performs as an OEM ECU, with good fuel consumption and power on demand when needed.

spit

Hardware Products

We offer a wide range of products
• Performance downpipes.
• Decat of exhaust.
• Stainless steel mandrel bent exhaust systems.
• Cold air intake systems.

Vehicle Servicing

• We offer servicing to all makes and models of cars.
• Major and minor servicing.
• Engine rebuilds.
• We are an RMI approved service center.

Diagnostics

We do full diagnostics and are equipped with the latest automotive diagnostic units.
Where problems cannot be detected with normal diagnostic tools we have automotive scopes to measure all signals between sensors on engine and ecu. In this case we put the vehicle on the dyno to do measurements and tests.